|
Home / Fitness / Equipment
How to replace your treadmill belt
By:Treadmillman
Is your treadmill belt worn, torn or curling up on the edges? Does your treadmill slow down after you step on the belt and begin your workout?
If this is the case then it may be time to replace the belt.
Here are some thing to check before replacing your belt.
*1. You need to make sure the deck of the treadmill is in good shape. If it looks good then it may only need to be waxed or lubricated.
*2. If the deck shows obvious signs of wear, or has grooves worn into it then you may need to replace the belt and the deck.
*3. If the deck looks good, and the belt is worn or starting to turn up on the edges then it is time to replace the belt. Here are the instructions for doing that. Most treadmills are basically the same so this is a generic set of instructions. If you have an owners manual please follow the manufacturers instructions.
To begin the belt replacement unplug the POWER Cord and remove the motor cover or hood. Then locate the screws or bolts that are used to adjust the belt tension. They are normally on either side at the rear of the treadmill. Loosen both sides and push the rear roller toward the deck.
Now loosen and remove the front roller. If your treadmill inclines, turn on the power and raise the treadmill a few degrees so the roller can be removed. After the front roller is removed, remove the rear roller. Now you are ready to remove the belt.
I know it would be easier to just cut the old belt off, but if you take it off in one piece then you will remember how to put the new one on. Along the sides of the treadmill you will find bolts or screws that hold the deck in place. Remove these and lift the deck and old belt out together. Now is the time to wax or lubricate the deck.
Look at the old belt and the new belt. There will probably be a visible seam on the belt. Normally the belt should be installed so that the seam goes downward from left to right, much like a backward slash. Some belt manufacturers will mark the belt on the inside with an arrow pointing in the direction the belt should travel.
Slide the belt over the deck in the proper alignment and lay the belt and deck together back onto the treadmill. Start all of the screws or bolts before tightening them securely. Decks tend to get warped after a while so you may need to push or pull a little to get the screws started. I have found that it is a good idea to install the rollers before securely fastening the deck to the frame.
Pull the belt to the rear of the treadmill and slide the rear roller through it. Start the adjusting screws in the roller just enough so they do not fall out. Now slide the front roller inside the belt and replace the drive motor belt over the drive gear. Do this before you tighten the roller. After you get the front roller tight, then tighten the rear roller with the adjusting screws. Tighten each side equally until the belt feels snug on the deck.
Now turn the treadmill on. If the belt starts moving, carefully step on the treadmill while holding the side rails. If the belt stops then you need to adjust more. Step off the treadmill,and tighten each screw one full turn and step on the belt again. Repeat this process until the belt does not stop.
Now increase the speed to a fast walk, hold the handrails and apply downward pressure as you walk on the treadmill. If the belt stops or hesitates then adjust some more. Now increase the speed to a jog, probably around five m.p.h. Once again if you feel hesitation in the belt when your foot hits it, adjust it some more. Continue this process until you are satisfied that the belt is not slipping.
PLEASE be careful, if you do not think you can do this then pay someone to do it for you.
Please follow these directions for safe and efficient use of your treadmill for you and your family.
The procedures for checking these items are all in the Free Treadmill Report! http://www.treadmills.cc
Digg
del.icio.us
Blink
Stumble
Spurl
Reddit
Netscape
Furl
Article keywords: treadmill repair, treadmillmaintenance, treadmill belts, treadmills, how to repair your treadmill, replace treadmill belt, treadmill belt replacement instructions
Article Source: http://www.articles2k.com
Paul Webb- Paul has been in the medical and fitness repair business for almost thirty years. So he has seen many of the problems associated with treadmills and fitness equipment.
You can visit his website at treadmills.cc or treadmillsrepair.com
|
|
| Top Equipment Articles |
- 1). Where To Buy A Treadmill By :
Buying a treadmill? Chances are you'll want to comparison shop to find the best deal for you. Looking at all of the options available can often save you hundreds of dollars.
But where can you look?
There are in general 3 places you can buy your tread mill. This article will outline what you should know about each. You'll learn the advantages and disadvantages - to help you find the best treadmill buy.
|
- 2). Best Elliptical Machine: 5 Must-Have Features When Shopping By : Kathryn ONeill
So you're buying an elliptical machine? Elliptical machines give you a low impact, safe workout that burns a maximum amount of calories in the least amount of time.
But with all of the different elliptical brands out there, how do you choose the best one? Here are 5 key features to look for when shopping to help you find the very best elliptical machine.
|
- 3). Treadmills For Great Cardio By : Geoff Godfey
Treadmills machines are one of the best cardio vascular exercise machine and the most popular too. With the whole nation embracing the idea of fitness, treadmills machines are an essential part of the workout. They are easy, convenient to use, suit all budgets and can be used at home too. Therefore one doesn't necessarily have to visit he gym to stay fit.
|
- 4). Exercise Bikes Burn Calories By : Maggie McTavish
Exercise bikes are a good way of losing calories and cutting the flab. They are a good cardio vascular workout and make the calf muscles especially strong. Cycling or biking is a very good form of exercising, as it tones up the entire body. Exercise bikes are equally good for providing such a workout. In the comfort of the home or the gym, you can easily work out and at any time of the day.
|
- 5). Power Inversion Tables, Great For Bad Backs By : Jonathon Miller
Inversion tables are used by thousands of people to help them relieve their back pain. There are many sizes as well as models which are available. Depending upon your comfort factor, you can easily purchase an inversion table. These inversion tables can be purchased from many websites on the Internet or you can also purchase from a store. Please look for all the features before you decide that this is the best inversion table for you.
|
- 6). Finding the Right Trampoline For You By : Dave Carter
Trampolining is a great way to get fit while having fun, but how do you find the right trampoline for you? Like so many other products these days, including fitness equipment, there is such a vast array of shapes and sizes available that any choice can seem completely overwhelming. But if a trampoline seems like the right fun and fitness choice for you, here are a few tips to bear in mind before you step into the store.
|
- 7). Choosing Fitness Equipment Like A Treadmill By : Keith Kingston
A treadmill is a great investment in fitness so when thinking about choosing a piece of fitness equipment, a treadmill is often a popular choice. Studies have shown that people get more out of a treadmill than other fitness equipment, because it is natural to walk or run and you are more apt to stick with it for longer each session and keep using the equipment itself over a sustained period of time.
|
- 8). Is Refurbished Fitness Equipment as good as new? By : I Henman
People often shy away from Refurbished Fitness equipment, but generally this is only because they aren't familiar with the term refurbished. In today's world saving money is important. If you can cut costs without sacrificing value is the aim of the game. No matter if you're a seasoned deal hunter or just out trying find a bargain, a piece of refurbished fitness equipment may be just what you're looking for shape up your body and your bank account.
|
- 9). Why You Should Invest in a Home Gym By : Nazima Golamaully
Daily exercise is as important for our physical well being as it is important for our mental strength; we are strong and confident only when we are healthy. Just like we need a balanced diet everyday, in the same way we need daily all round exercise.
|
|
|
| New Equipment Articles |
|
|
|
|
- 3). Exercise And Swiss Ball Workouts By : Mike Singh
For those of you who are not familiar with the name, a Swiss Ball is a large plastic exercise ball that is used for a variety of fitness workouts. They are generally preferred by people who are looking to put strengthen their core muscles while improving their balance.
|
|
|
- 5). How To Choose Elliptical Trainers For Your Home By : Gregg Hall
Compared to running on air or gliding on a ski slope, elliptical exercise equipment also offers an entertaining, fun outlet from the monotonous routine of treadmill jogging and knee splitting stair climbing. When considering the purchase of one of these exercise giants, you will find a variety of options on the market to choose from.
|
- 6). Incline Treadmill Review By :
Most people buying a treadmill want one with an incline (also called treadmill elevation).
It used to be that incline on a treadmill was a bonus feature. However today, most motorized treadmills come with an incline option. The difference seems to be in the amount of elevation available.
If you're looking for an economy treadmill (under $1000) you'll probably find most treadmills only come with a 10-12% incline (however that can be enough for most people - especially for those new to treadmill exercise).
|
- 7). Trampoline Basics By : John Furnem
Trampolines are a wonderful thing, I don’t know if you have noticed but in the last few years more and more people are getting a trampoline for their backyard. My neighbor got one a few years ago and every time his kids would come and visit the grandchildren would spend most of their time on the trampoline or in its environment.
Some people think that trampolines are mainly used by kids, that trampolines are mere toys for kids to jump around and have fun.
|
- 8). Treadmills - Walking Your Way To Better Health One Step At A Time By : Maxine Schel
Walking is one of the most natural, everyday movements that an individual can make. For years, this simple act has been believed to help improve cardiovascular health, reduce stress and burn calories at the same time. Because not everyone has the convenience or the safety of walking outdoors, treadmills are designed to offer the same benefits without having to leave home.
|
- 9). Stationary Bikes Save You Money By : Faith Armstrong
If you have decided to use a fitness facility when riding stationary bikes consider factors that can make that more enjoyable. And consider factors other than price if at all possible. Save money by not eating fast food as often and use the money saved to pay for a club that is better for your purposes or even to rent an apartment with a fitness center over one without.
|
- 10). Recumbent Stationary Bikes By : Prima Nero
The world of stationary bikes and exercise equipment in general is on the verge of major revolution. This may be due in part to the overwhelming success of such interactive video games as Dance Dance Revolution. An orthopedic surgeon from Denver, Ted Parks, devised Gamebike to use with the Sony Playstation console. The players actually pedal to play the games in the same way that Dance Dance Revolution players must dance on a dance pad to interactively play those games.
|
|
|
