|
Home / Home / Home Improvement
How to Select and Install a Home Well Water Chlorinator
By:Gerry Bulfin
Common household bleach can used in an automatic chlorinator system to kill coliform bacteria and provide disinfected water. In some wells iron or sulfur bacteria can create 'rotten egg' odors and cause staining of fixtures and appliances. Chlorinators can also be used to address these problems.
The first step in selecting a chlorinator is to find out your basic water chemistry and have your well water tested. A general mineral analysis will provide a list of the common minerals (calcium, magnesium, iron, manganese, dissolved solids) alkalinity and pH. The pH is important because the higher the pH the more chlorine is required.
How Much Chlorine Should I Plan to Add?
Chlorine is injected in parts per million ('ppm') which is the same as saying milligrams per liter ('mg/L'). For bacteria you want 1 to 2 ppm of chlorine and approximately 10 minutes of contact time. If the water is colder than 50F you may need longer contact time.
For each part per million of iron or manganese you want to inject 1 ppm of chlorine. For each 1.0 ppm of hydrogen sulfide gas (which causes the rotten egg smell in water) you want to inject 2 to 3 ppm of chlorine.
So say you have bacteria and 2.0 ppm of iron. For our example here, we will assume you want to inject 3 ppm of chlorine.
How Do I Know What Size Chlorinator Pump to Install?
The next step in selecting your metering pump is to know how many gallons per minute your well water is flowing at the point where you will be injecting the chlorine. Usually the best place to inject the chlorine is before the pressure tank. Unless you have a variable-speed pump, your water at this point is flowing in approximately the same flow rate every time the well pump turns on. After you use up your reserve in your pressure tank, the pressure switch turns on the well pump and the water begins to flow from the well.
You can easily calculate the flow rate at this point by following these steps:
1. Open any hose bib or faucet until pump turns on.
2. Close hose bib or faucet and let pump fill up pressure tank until it turns off.
3. Using a 1 or 5 gal. bucket, open faucet, collect and measure all water discharged until pump turns on. Let us say this amount is 20 gallons.
4. When pump turns on, immediately close faucet and start timing pump cycle.
5. When pump turns off, record pump cycle time to refill pressure tank in seconds. Let us say this figure is two minutes or 120 seconds.
6. Divide the number of gallons collected in Step 3 by the number of seconds in Step 5. 20 divided by 120 is 0.166
7. Multiply the answer from Step 6 by 60, which comes out to 10.
8. The answer in Step 7 is the average pumping capacity of the pump in gallons per minute (GPM).
Now that you know the amount of chlorine you want to install (3 ppm) and the flow rate of the water stream you are injecting the chlorine into (10 gallons per minute) you are finally ready to calculate the size of the metering pump!
How Strong Should the Chlorine Bleach Solution Be?
Use unscented 5% chlorine laundry bleach and dilute it by adding 9 gallons of water to 1 gallon of bleach. This will give you a solution strength of 5000 parts per million of chlorine.
Metering Pump Sizing
Metering pumps are often rated in the amount of chlorine solution they can pump by gallons per day. They have adjusting knobs so you can pump the full output or turn the pump down to deliver up 90% less than the output.
The formula simple: multiply the flow water (GPM) times the Applied Dosage in Parts Per Million and them multiply this by 1440 (the number of minutes in on 24 hour period). Finally divide this number by the solution strength being used.
10 GPM x 3.0 PPM x 1440 divided by 5000 = 8.6 Gallons Per Day
At this rate you can select a metering pump that can pump 10 gallons per day and adjust the output of the pump to 86% to achieve the desired 8.6 gallons per day. Finally you can test the chlorine residual at the kitchen sink. Your goal should be to have a residual of 0.2 to 0.8 ppm of chlorine. If you find the residual is too high, you can adjust the metering pump down to deliver less or dilute the chlorine solution with more water. If you find the residual is too low, you can make the solution strength stronger by using less water to dilute the solution, or you can turn up the output of the metering pump.
Digg
del.icio.us
Blink
Stumble
Spurl
Reddit
Netscape
Furl
Article keywords: chlorinators, coliform, chlorine, chlorine metering pump, metering pumps, sizing metering pumps
Article Source: http://www.articles2k.com
Gerry Bulfin is a licensed water treatment contractor and WQA Certified Water Specialist IV specializing in treating contaminated or problem well water. He may be contacted through the website www.cleanwaterstore.com or by calling 831-462-8500 or by emailing him here.
|
|
| Top Home Improvement Articles |
- 1). Installing Ceramic Tile in a Shower By : Mark J. Donovan
Installing ceramic tile in a shower starts with a proper foundation. The foundation consists of WonderBoard or Durock cement board on the walls and a Shower Pan Membrane Liner in the base of the shower, if the shower floor is to be tiled too.
WonderBoard or Durock cement board, also known as backerboard, are resistant to water and are ideal materials for applying ceramic tiles to high-moisture areas.
|
- 2). Ideas For Kitchen Nooks By : T Agee
For many, the most popular room in the house is the kitchen. If you have a kitchen nook that goes along with that, then you’re lucky. But you may also be stumped for how to decorate your nook. Luckily, there are countess options available to you.
One thing that you will want to do is choose a style for your nook that won’t overwhelm the kitchen itself.
|
|
|
- 4). Vanities Are Not Just Plain Wood Anymore By : T Agee
It used to be that a bathroom sink vanity was a fairly plain piece of cabinetry with doors underneath and perhaps a set of drawers for storage on one side. Not anymore. Homeowner’s today are leveraging all sorts of interesting materials to create a custom vanity.
In fact, one of the most popular bathroom styles these days is to forgo a vanity all together by utilizing old-fashioned pedestal sinks.
|
- 5). Benefit From The Stylish Look Of Vertical Blinds By : Peter Wilson
Every homeowner wants to make his or her property look as good as possible, both inside and out, and part of doing this is to select the right décor. Selecting the right window coverings is an integral part of getting the right look for home, and can make a big difference to the look and feel of any room. The contemporary look of vertical blinds is a valuable addition to any home improvement, and whatever type of decoration theme you have in the room these window blinds can give the perfect finish.
|
- 6). 10 Tips For A Window Coverings Makeover By : Rob Carlton
You cannot stand it. The same old dreary windows that do little to add life to your home. It is time for a change. But, where do you start? How do you keep from making an expensive or embarrassing mistake? In fact, how can you know what you really want?
1.Start with one room at a time.
There may be the temptation, especially when moving into a new home, to decorate all of the rooms at once.
|
- 7). Closet Organizers - Bringing Order To Messy Closets! By : Caroline Smith
Closet organizers are cleverly designed to optimize the use of the space available, and can work wonders at transforming a cluttered closet into a neat and tidy storage place. We all know how annoying it is to have an a closet crammed full of old clothes and to never be able to find what we're looking for. Or when we do find that favorite dress, all too often it's lying in a crumpled heap at the bottom of the closet.
|
- 8). The big surprise with a Sectional sofa. By : Kenneth Langlet
Have you ever had a sectional sofa in your home? If not you are in for a big surprise. The sectional sofa that you can decorate your family living area with is one that is going to complete your style. You can find a sectional sofa that uses plants, animals, that is a solid color that will be made of stripes and even a sectional sofa that will be customized to match your drapes.
|
|
|
- 10). Making A Splash In The Kitchen: Suggestions For Spicing Up Your Backsplash By : Jason Flintstone
If it's true that the way to a man's heart is through his stomach, then it should come as no surprise that women want a beautiful yet practical kitchen with all the comforts and amenities the queen of the castle deserves. Let's face it, trendy, healthy meals take time and space, and part of creating beautiful meals means creating a beautiful environment to prepare them in.
|
| New Home Improvement Articles |
- 1). Basement Finishing Ideas For DIY Enthusiasts By : Isabel Baldry
Basements can be a major selling point when it comes to real estate. Many people like having a finished basement for many different reasons. For those with a little DIY knowledge the basement can easily be turned into the best spot in the house.
|
- 2). This Is Why You Should Choose Solar Power By : Bryan Wong
The amount of solar power that the Earth receives from the sun is estimated to be 770 trillion kilowatts or an amount 5,000 times bigger than the sum of all energy resources we are using. You can also profit from this and save money read here how...
|
|
|
|
|
|
|
- 6). Methods to Control Mosquitos By : Gail Metcalf
You need to protect yourself from mosquitoes. When you think about mosquito pest control by netting, you could break it down into individual control and public control.
|
- 7). Kitchen Remodeling from a Tropical Paradise By : Chris Campbell
Having your kitchen remodeled is really no big deal, as long as you do it while your lying on the beach. Preferably a beach on a warm tropical island, with a pleasant trade wind keeping your margarita cool from the oh so scorching rays of the sun.
|
- 8). Get Yourself A Home Improvement Book By : William King
A home improvement book can help you with all of your remodeling needs. A good book will be full of information on how to get the job done right. If you are unclear about how a job needs to be done, referencing it in a book can be a major benefit to you.
|
- 9). Ideas For Kitchen Nooks By : T Agee
For many, the most popular room in the house is the kitchen. If you have a kitchen nook that goes along with that, then you’re lucky. But you may also be stumped for how to decorate your nook. Luckily, there are countess options available to you.
One thing that you will want to do is choose a style for your nook that won’t overwhelm the kitchen itself.
|
- 10). Vanities Are Not Just Plain Wood Anymore By : T Agee
It used to be that a bathroom sink vanity was a fairly plain piece of cabinetry with doors underneath and perhaps a set of drawers for storage on one side. Not anymore. Homeowner’s today are leveraging all sorts of interesting materials to create a custom vanity.
In fact, one of the most popular bathroom styles these days is to forgo a vanity all together by utilizing old-fashioned pedestal sinks.
|
|
|
